Replacing the fuel filter on Daewoo Nexia With your own hands - instructions with photos are presented in the article. To replace the fuel filter on Daewoo Nexia Need small set Tools, as well as a bit of free time.
The content of the article:
Fuel filter is one of important elements fuel system of any car, main function Which is to purify it from impurities. Due to the insufficient fuel quality, and over time you need to replace the filter element. This article will discuss how to independently replace the fuel filter by car Daewoo Nexia.
Where is and when changing the fuel filter on Daewoo Nexia
The Nexia car is equipped with a full-flow fuel filter, which is located in the back of the car body next to the fuel tank and is attached to the longitudinal beam with a special clamp. The tubes of fuel highways are screwed using threaded connections. The filter is a cylindrical steel housing, inside of which the filter element is located.
Gasoline sold at gas stations is not distinguished by excellent quality and often there are various impurities in it. And the tanks that are used for storage and transporting fuel are subjected to various contaminants, as a result of this rust and pollution can get into gasoline. All listed factors adversely affect the quality of fuel.
To warn the fuel system from the occurrence of corrosive processes and premature wear, a car device is provided by a filter element. The main function of which is to clean the fuel from impurities and foreign particles.
When the car filter is clogged, then this will manifest as follows:
- loss of car power;
- increase fuel consumption;
- bad launch and unstable engine operation;
- on the high revolutions Rod appear jerk.
According to the regulation of the service book on holding, performing the replacement of the filter element every 10,000 km of mileage. It is simply clear, you can even take the rule that, with each oil change, you should also replace the fuel filter.
Preparation for replacing Filter on Daewoo Nexia
Before replacing work, you should prepare the necessary tool and the actual filter itself. From the tool you will need:
- horn keys at 13, 16 and 21;
- capacity for fusion gasoline;
- wooden plugs.
And of course a new filter. It is also worth noting that complete with the filter must be two copper washers. If they are absent, then they need to buy them. Regarding the choice of filter, it should be said that it is still better to use original spare parts, However, the choice remains for the owner. Regarding the location of the fuel filter in the car Daewoo Nexia, it is worth noting that it is hard to call it successful. If the work is performed not on the lift, then it takes a slightly raise the rear right part with the help of a jack.
Fuel filter replacement procedure by Daewoo Nexia
When all required tools and spare parts are prepared, you can proceed to work that look like this: 
Thus, work is performed on replacing the fuel filter in the Daewoo Nexia car. Based on the work done, it is worth noting that the replacement does not need complex skills, just a little free time and desire.
Video - Replacing the fuel filter on Daewoo Nexia:
Our store carries out the delivery of spare parts in coordination with the client and if there is such an opportunity. True, is restriction on the minimum order amount starting with which delivery possible - 2000 rubles . This is caused by purely economic reasons and are very pleased to consider and come for a nut or, for example, a filter on its own. Our address and ways to come to us on the page.
The cost of our delivery
Shipping cost of spare parts from our store in Moscow (within the Moscow Ring Road) - 500 rubles. (Attention: delivery is possible with an order amount of at least 2000 rubles)but at the same time our store can not guarantee compelling Delivery. Delivery service - "if possible."
But if the purchase amount reached 5000 rubles, then the delivery within Moscow will be free!
Delivery in the suburbs is as possible, but by prior arrangement and on the "contractual" price.
Time of delivery
The delivery time is consistent with the forwarder, which will surely contact you shortly after you place your order.
Attention! Incorrectly specified phone number, inaccurate or incomplete address can lead to an additional delay! Please carefully check your personal data when checking out the order. The confidentiality of your registration data is guaranteed.
Delivery is performed daily from 10:00 to 19:00, a delivery can also be performed on Saturday, but by prior arrangement. On Sunday there is no delivery. The goods ordered by you on Saturday and Sunday are delivered on Monday or on Tuesday.
Place of delivery
Delivery is carried out at the address specified when placing the order. If you need to deliver goods to another address, you must inform the address to the manager, which will contact you immediately after placing the order on the site.
rules
When delivery you will be transferred to all required documents For a purchase: invoice, cash check. When making a purchase on the organization, the originals of the account and the invoice will be transferred to you, as well as the invoice in which you need to put the seal of your organization and the signature of the responsible person. The price specified in the courier documents transferred to you is the final, the courier does not have the right to adjust the price. The shipping cost is highlighted in the purchase documents of a separate line.
Attention! Please remember that all technical specifications, consumer properties, and, most importantly, the use of acquired spare parts precisely to your car you should clarify our manager until the purchase of goods! The duties of the delivery service workers do not include the implementation of consultations and comments on the applicability of spare parts and the methods of their installation. When receiving the ordered goods delivered to you, please check in the presence of the courier: the completeness of the delivered goods, the lack of damage on body parts, chips and cracks on the glasses, the compliance of the goods delivered to the product on our website. With a statement by you upon receipt of the goods of claims about mechanical damage, there are no such claims in the future. In the event of questions, wishes and complaints, please contact us in the following coordinates.
Fuel filter In any car it consumables. As you need, it needs a timely replacement. From this article you will learn how to replace the fuel filter on Daewoo Nexia with your own hands. First of all we can congratulate you, you found the most complete and detailed instructions By replacing the fuel filter with photos and video.
Fuel filter on NexiaIt is recommended to replace the fuel filter no later than 40 thousand kilometers as recommended by the manufacturer. Ideal for replacement there will be a figure of 10 thousand kilometers, this is associated with poor gasoline quality.
The manual is universal for all nonsense and suitable for cars until 2008, as well as restyling after 2008 (N150), 8 valve and 16 valves.
Often, to determine the question, it is time to change the fuel filter or not, it suffices to identify the symptoms. For example, on high engine speeds there will be jerks when moving, the engine seems to be twitching and not react to gas. Often this indicates clogging of the fuel filter or the absence of gasoline. There is no need to wait for the manifestation of these symptoms, it is better to change consumables on time.
Preparing for filter replacement
First of all, it is necessary to prepare tools and materials, such as a fuel filter, can be ordered on the Internet, and this may use our article with numbers on filter consumables. (See Squance Filters).
Also at the replacement of the fuel filter on nexia there is one feature. It is necessary to buy rare keys to 16 and 21.
We will need:
- Keys at 13, 14, 16 and 21;
- fuel filter
- Copper washers (suitable from the vase, in case there is no complete with a new filter)
- 200 ml container for gasoline drain
Instructions for replacing the fuel filter
Before performing the work, be sure to reduce the pressure in fuel system. Otherwise, you risk a lean from the legs to the head of gasoline. In order to reset the pressure in the fuel system on Nexia You must get the fuse F7 and start the engine. The car will work on fuel residues and then it will stall. This will mean that there is no gasoline in the fuel highway. After that, you can proceed.
The fuel filter is under the bottom of the car - on the right side under the passenger door.
Fuel filter location 1. Hold down the fitting with one key, unscrew the fuel tube nut on one side of the old filter. In the same way, unscrew the nut on the other side.
Replacing the fuel filter When turning the fighting, put a container for flowing fluid. Approximately leaks up to 120 ml when replacing, provided that the pressure in the system was reset.
2. Next while holding the filter fastening bolt, unscrew the nut with a nut holding the fuel filter. After performing this procedure, remove the fastening clamp and pull out the old filter. Take out the tubes carefully, they are easily bent and burst.
Fastening the fuel filter on nonexia 3. Install a new filter with sealing rings in the reverse order. Please note that it is necessary to correctly install the fuel filter on the nonxica in the direction along the movement of fuel from the tank into the engine. On the filter housing, the direction arrow or inscription in In, it means that the inscription should be from the gas tank side. In the installation of a new filter, first fuel the fuel tubes from hand so that the carving enters exactly into the hole, otherwise the gasoline will be reduced.
ATTENTION
After replacing, do not forget to install the fuse back, as well as start the engine and on the engine running, check the tightness of the tubes connections. If it happens, tighten the nuts or replace the sealing washers (rings).
Video to replace the fuel filter on Nexia:
According to the regulations, the fuel filter in Daewoo cars Nexia is subject to replacement every 40 thousand km of mileage, or after every two years of work. But taking into account the quality of our fuel, it can be replaced much more often. To select a fuel filter to Nexia, use the table contained by filter manufacturers and catalog numbers models.
| MANUFACTURER | VENDOR CODE |
| ORIGINAL | |
| Daewoo. | 25055129 |
| Analogs | |
| Asam | 30523 |
| MAPCO. | 62512 |
| Ford | 1137438 |
| Knecht. | 25055129 |
| Daewoo. | 96130396 |
| GM. | 96130396 |
| JPN. | 96130396 |
| O.E. | 96130396 |
| Onnuri. | 96130396 |
| Bosch. | 986450119 |
| Profit. | 1530-2903 |
| Ashika. | 30-03-393 |
| TSN. | 931Al |
| PMC. | 96130396_PMC. |
| DENCKERMANN. | A110016. |
| Blue Print. | ADG02302. |
| AMD. | AMDFF29. |
| Premium. | B30001Pr. |
| Japan Cars. | B30008D. |
| Toko Cars. | BK3-001TOKO. |
| AMC. | DF7740. |
| Mecafilter. | Ele6019. |
| Japanparts. | FC-393S. |
| Fortech | FF001. |
| Amp | FF1101 |
| Goodwill | FG601 |
| JS Asakashi. | FS481J. |
| Fiaam | FT5294. |
| Kap. | G03FULSD00144. |
| Interparts. | IPF-D001. |
| Nipparts. | J1330900. |
| Kemp. | KE4203. |
| Lynx | LF1117. |
| Mann. | Mann WK 612/2. |
| Parts-Mall. | PCC-002. |
| Filtron. | PP859. |
| Bugus. | QIN3727. |
| Alco. | SP-2083. |
| SCT. | ST 329. |
| WIX. | WF8064. |
Instructions for replacing the fuel filter on Daewoo Nexia + photo report
1. The fuel filter in Nexia is located under the bottom to the right of the gas tank, so the car will need to drive onto the flight, pit or just subdominate.
Replacing Fuel filter Daewoo Nexia 2. Now, in order not to be lined with gasoline during the process, you need to discard the pressure in the fuel system. To do this, open mounting block, we find a fuse fuel pump With the label F7 and remove it from the landing socket.
3. Run the engine and let it work for a few seconds. Basonasos at the same time will not work and the pressure in the system will fall.
4. Find the fuel filter. The keys are 21 and on 16 unscrew the fuel line fitting from the filter first on one side, then on the other. At this time, there is a small amount of gasoline.
5. The key to 13 unscrew the bolt of the clamp, which is fixed by the filter.
On the need to replace the fuel filter and monitoring its condition itself, the quality of fuel at our refueling. Regulations dEU service Nexia advises to do this when running 40 thousand km. However, given the conditions of operation and the comparative simplicity of work, it is better to reduce the mileage before replacing up to 15-20 thousand.
Where is the fuel filter of fine cleaning in Daewoo Nexia
Full-current fine cleaning filter is located in the back of the car to the right of the fuel tank.
His task - Protect the nutrition system from harmful impurities and small suspension particles. Even considering what's in fuel tank There is a coarse filter, it is not able to fully protect the injection system from the smallest particles. If there is a suspension in the nozzles, their resource is significantly reduced, the operation of the injection system deteriorates. In addition, the fuel filter protects the fuel line and the elements of the system from corrosion caused by an inevitable moisture in the fuel.
What is better to choose?
To replace the old filter, both in eight and in 16-valve modifications, the plant recommends using corporate Korean Filter Daewoo with articula 25055129 .
Nevertheless, many use less expensive analogs. MANN, FRAM, PROFIT, VALEO, STELLOX . Their price ranges from 300 to 800 rubles, depending on the brand, since to buy an expensive filter, given the short replacement time, not always profitable.
Required Replacement Tool
To remove the fine-cleaning filter is more convenient to 16 and 21 hornword keys on 16 and 21, pre-refined using a grinder.
To replace the filter will be useful:
- Cute keys on 16 and 21.
- Standard tool kit.
- Penetrating lubricant WD40.
- Capacity for the drain of gasoline from the old filter.
- The new filter with seals (not included).
Detailed algorithm
First you need to lose pressure in the fuel line. To do this, you need to get to the power contacts of the gas station.
- The fuel pump is installed in the fuel tank, and access to its power contacts opens through the rear seat hatch.
- Therefore, we remove the pillow, we fold the valve, remove the plastic lid lid and carefully remove the electrical connectors on the fuel pump.
- Run the engine, it should work on idling and stall through 15-20 seconds When all the fuel generates.
Turn off the ignition and proceed to replacing the filter. It is more convenient to work on the lift or observation pit.
- Remove the minus terminal on the battery.
- Hold the fuel filter with a key to 21, and we unscrew the input and output fitting with the key to 16. At this stage, difficulties may occur, since the location of the filter is such that all moisture and dirt from under the wheels gets straight on it. It is better to treat fittings and fastening bolt of the filter housing clamp in advance.
To avoid breakdown nuts, soak the connection places with penetrating lubrication.
- We set the capacitance under the filter and drain the gasoline remaining in it.
- Out of the head on 13 or precipitant key, unscrew the bolt of fastening the clamp.
- We take a new filter and find an arrow on its body, indicating the direction of the fuel movement.
- We screw the new filter with a clamp bolt.
- Control the condition rubber pads in fittings. If bad - replace.
Gaskets are better to change in any case.
- We screw the hands of both fittings in place, after that we fix the success of the keys to 21 and 16.
We establish a new filter and connect the fuel tubes, observing the direction by the elder.
- We put on the terminals on the fuel pump and on the battery and let the engine. Control the tightness of the fittings on the filter.
conclusions
With the slightest signs of fuel leaving the moach and eliminate the malfunction. So you can quickly change the fuel filter on Daewoo Nexia with your own hands. Pure all gasoline and good roads!
Video about what is inside the Daewoo Korean Fuel Filter
