When is it generally necessary to replace the oil in Volvo automatic transmission (Volvo)?
Replacing Oil automatic transmission Volvo (Volvo). How does this happen and what butter in the CorBRU volly pour?
Procedure full replacement Transmission oils are always performed using special equipment that runs from the car transmission pump. The installation is connected to the mode of the cooling line of the automatic transmission, and while the old liquid is dumped using the automatic transmission pump itself, new liquid In the same quantity for the time of time arrives back into the pallet of the box. In this case, the waste liquid is simply merging into a suitable container. Sometimes an additional cleaning is performed by adding a special Wynns additive before the procedure that removes the contamination from the old transmission fluid from the channels, the torque converter, the cooling lines and the internal components of the automatic box. The main advantages of this procedure is that all transmission fluid is removed and replaced by a new one. This procedure for complete replacement of automatic transmission oil differs from a liquid change in the traditional method at which only part of the fluid is replaced. A simple partial replacement of fluid cannot remove all internal contaminants that accumulate over time. In addition, some of the old liquid usually remains in the hydrotransformer and after the bay the new liquid mixing with the old loses its properties. What is the point of this?
Original oil in Volvo box - automatic transmission 1161640 (1161540) corresponds to the analogues of Mobil JWS 3309 and Toyota Type IV, and 1256775 (31256774) similar to other manufacturers and marked as, Toyota WS Part No. 00289-ATFWS, GM Automatic Transmission Fluid Type AW1 93165147, ACDELCO 19256039 - General Motors (USA), Ford Motorcraft® MERCON® LV XT-10-QLVC or from the manufacturer of AISIN ATF-0WS automatic transmission. All of the above liquids comply with Volvo requirements for TF-80SC-TRANSMISSION FLUID AW-1, and they can be used instead of the original Volvo 31256775.
So, the complete oil change in Volvo automatic transmission (Volvo) is good or bad?
For many years in a row, we constantly hear from new customers of our discussion on the topic of ways to replace the oil automatic transmission Volvo and its necessity.
Many owners vOLVO cars C. automatic box The programs received incorrect information and are generally confident that the oil is filled into the automatic transmission "forever" and the automatic transmission is non-servant. The resource of the modern synthetic fluid is filled into the automatic transmission of the car Volvo quite enough for the time warranty period Use the car and this is enough for the manufacturer. Term - "polished for the whole service life and does not need to be replaced when normal conditions Operating "is unwritten not entirely correct. However, when operating a car in urban traffic jams, frequent short trips to "Taxi mode" - the manufacturer recommends changing the transmission fluid every 60 thousand kilometers. All mechanics and experts unequivocally agree that the net transmission fluid will allow to extend the service life of the gearbox, so the procedure wrong automatic transmission oil replacement (Volvo) Installation Wynns is best way to achieve this goal.
One of the greatest misconception about the complete replacement of the oil is a focused on the fact that the replacement process occurs with the installation of a "high pressure", which literally pushes the liquid in the automatic transmission line in the opposite direction from the normal fluid flow, which may damage the components or squeeze Sloves and seals. When the fluid forcibly piled back into the gearbox, pieces of garbage, the so-called "useful deposits" can shift and it is possible to score the filter, block the narrow channels or one-sided valves ...
This is nothing more than a myth based on incorrect information.
Many car manufacturers directly recommend using Special Equipment - Transmission Fluid Exchanger to replace the automatic transmission oil and only in its absence to replace the automatic transmission oil using the automatic transmission using the automatic transmission. Almost all the car dealers have in their arsenal of installing Wynns Transerve and constantly use them.
Check the quality and level of transmission fluid
In the past each vehicle There had a tramsion probe that was used to verify the quality and ATF level. For cars, which are still equipped with such a dipstick, ATP testing occurs very easily. On all Volvo cars with a dipstick in the automatic transmission (AW-55-51SN 5), the level check is performed when the engine is running and the transmission position in P Park. Check is performed operating temperature.
If you do not have information about what automatic transmission is on your car, refer to the user manual or contact us and we will be happy to give you answers to some technological processes.
All new cars Volvo have no shut off automatic transmission. On these machines, the fluid level is checked from under the vehicle, it is necessary to remove the engine protection. Moreover, the fluid level is checked at a certain temperature, respectively, without a scanner to determine the temperature of the transmission fluid, do not do. Therefore, if you do not have a certain experience and knowledge contact us.
Normal transmission fluid may be brown and should not be smelling Gary. The darkening of the fluid occurs due to the natural wear of the clutch packages and this is normal, however, if large particles appear in the transmission fluid, and the oil has the smell of Gary, it may indicate some serious problems.
Short trips and car traffic jams make themselves known to 45-50 thousand mileage. The transmission fluid loses its properties due to the contamination of wear products and it is manifested in the appearance of jerks or jogs when shifting gear. Or, more simply, the gear shift becomes more noticeable, which is the first reminder that urgent Replacing Oil automatic transmission Volvo (Volvo). Because of the transmission fluid contaminated by abrasive products, the automatic transmission of automatic transmission is primarily wearing, so you need to understand that the quality of work automatic transmission Directly depends on the state of the working fluid. 
Replacing butter in Volvo XC70 automatic transmission 2012 release is another, already 2nd replacement on this car, used original oil in box Volvo- Volvo. 31256775.
Primary replacing Oil automatic transmission on this Volvo XC70 It was performed simultaneously with the revision of the thermostat of the automatic transmission (now it is in constant open state) and.
With the previous replacement of transmission fluid, the car ran over 55 thousand km and its mileage was 120800km.
What is important to note - with an additional automatic transmission radiator from the client for the last 55 thousand kilometers, there were no complaints about the operation of the automatic transmission, pressing when switching from N per D is missing, which is extremely rare for cars from the 2011 model year of release.
P.S from the moment of updating the variety of information passed for about a year and now on 01/12/2017 this car Signed by 195.00 km. The oil in the automatic transmission is replaced during this period twice installing Wynns on ATF WS Toyota. The box works correctly 
The Wynns Transerve installation is connected to the automatic transmission of the ACP. 
Here is the process of replacing the automatic transmission oil on the Volvo XC70 by installing Wynns. 
The exhaust fluid merges and shows its color. 
At the end of the process, it can be seen that there is already a completely clean ATF. 
The box temperature fell to the desired indicator and is in the range of 50 to 60 degrees. Now you can check the level in the automatic transmission. 
Checking the level through the control hole aISIN automatic transmission TF-80SC.
In some cases, it may be necessary to stop the control hole 30713219 and the sealing ring 1233068 to carry out a complete procedure of the automatic transmission, 12 liters of ATF are required. A slightly more transmission fluid is taken to compensate for the mixing effect.
Types transmission fluids Mogute differ depending on the automatic transmission model and the year of the car.
The procedure for replacing the automatic transmission oil usually takes 2-2.5 hours.
- AW 55-51SN-5 stupas. model year - from 2003-2014 - 12500 rubles. (Mobil JWS-3309 12 liters)
- TF 80SC -6 stupas. Model year 2005-2010 Generation 1 - 12500 rubles. (Mobil JWS-3309 12 liters)
- TF 80SC -6 stupas. Model year C -2011 Generation 2 - 14000 rub. (Toyota-ATF WS 12 liters)
- TF 80SC -6 stupas. Model year C-2011 Generation 2 -18000 rub. (Original oil Volvo 31256775 12 liters)
When is it generally necessary to replace the oil in Volvo automatic transmission (Volvo)?
Replacing Oil automatic transmission Volvo (Volvo). How does this happen and what butter in the CorBRU volly pour?
The procedure for complete replacement of gearboxes is always performed using special equipment that runs from the car transmission pump. The installation is connected to the time of the automatic transmission line of the automatic transmission, and while the old liquid is pumped out with the help of the automatic transmission pump itself, the new liquid in the same quantity for the time for the time of time arrives back into the pallet of the box. In this case, the waste liquid is simply merging into a suitable container. Sometimes an additional cleaning is performed by adding a special Wynns additive before the procedure that removes the contamination from the old transmission fluid from the channels, the torque converter, the cooling lines and the internal components of the automatic box. The main advantages of this procedure is that all transmission fluid is removed and replaced by a new one. This procedure for complete replacement of automatic transmission oil differs from a liquid change in the traditional method at which only part of the fluid is replaced. A simple partial replacement of fluid cannot remove all internal contaminants that accumulate over time. In addition, some of the old liquid usually remains in the hydrotransformer and after the bay the new liquid mixing with the old loses its properties. What is the point of this?
Original oil in Volvo box - automatic transmission 1161640 (1161540) corresponds to the analogues of Mobil JWS 3309 and Toyota Type IV, and 1256775 (31256774) similar to other manufacturers and marked as, Toyota WS Part No. 00289-ATFWS, GM Automatic Transmission Fluid Type AW1 93165147, ACDELCO 19256039 - General Motors (USA), Ford Motorcraft® MERCON® LV XT-10-QLVC or from the manufacturer of AISIN ATF-0WS automatic transmission. All of the above liquids comply with Volvo requirements for TF-80SC-TRANSMISSION FLUID AW-1, and they can be used instead of the original Volvo 31256775.
So, the complete oil change in Volvo automatic transmission (Volvo) is good or bad?
For many years in a row, we constantly hear from new customers of our discussion on the topic of ways to replace the oil automatic transmission Volvo and its necessity.
Many owners of Volvo cars with automatic transmission received incorrect information and are generally confident that the oil is flooded in the automatic transmission "forever" and the automatic transmission is non-maintained. The resource of the modern synthetic fluid is filled into the automatic transmission of the car is quite enough for the time of the warranty period of using the car and this is enough for the manufacturer. The term is "flooded for the entire service life and does not need to be replaced under normal operating conditions" is not entirely correct. However, when operating a car in urban traffic jams, frequent short trips to "Taxi mode" - the manufacturer recommends changing the transmission fluid every 60 thousand kilometers. All mechanics and experts unequivocally agree that the net transmission fluid will allow to extend the service life of the gearbox, so the procedure wrong automatic transmission oil replacement (Volvo) Installation WYNNS is the best way to achieve this goal.
One of the greatest misconception about the complete replacement of the oil is a focused on the fact that the replacement process occurs with the installation of a "high pressure", which literally pushes the liquid in the automatic transmission line in the opposite direction from the normal fluid flow, which may damage the components or squeeze Sloves and seals. When the fluid forcibly piled back into the gearbox, pieces of garbage, the so-called "useful deposits" can shift and it is possible to score the filter, block the narrow channels or one-sided valves ...
This is nothing more than a myth based on incorrect information.
Many car manufacturers directly recommend using Special Equipment - Transmission Fluid Exchanger to replace the automatic transmission oil and only in its absence to replace the automatic transmission oil using the automatic transmission using the automatic transmission. Almost all the car dealers have in their arsenal of installing Wynns Transerve and constantly use them.
Check the quality and level of transmission fluid
In the past, each vehicle had a tramsion probe that was used to verify the quality and ATF level. For cars, which are still equipped with such a dipstick, ATP testing occurs very easily. On all Volvo cars with a dipstick in the automatic transmission (AW-55-51SN 5), the level check is performed when the engine is running and the transmission position in P Park. Check is performed at operating temperature.
If you do not have information about what automatic transmission is on your car, refer to the user manual or contact us and we will be happy to give you answers to some technological processes.
All new cars Volvo have no shut off automatic transmission. On these machines, the fluid level is checked from under the vehicle, it is necessary to remove the engine protection. Moreover, the fluid level is checked at a certain temperature, respectively, without a scanner to determine the temperature of the transmission fluid, do not do. Therefore, if you do not have a certain experience and knowledge contact us.
Normal transmission fluid may be brown and should not be smelling Gary. The darkening of the fluid occurs due to the natural wear of the clutch packages and this is normal, however, if large particles appear in the transmission fluid, and the oil has the smell of Gary, it may indicate some serious problems.
Short trips and car traffic jams make themselves known to 45-50 thousand mileage. The transmission fluid loses its properties due to the contamination of wear products and it is manifested in the appearance of jerks or jogs when shifting gear. Or, more simply, the gear shift becomes more noticeable, which is the first reminder that urgent Replacing Oil automatic transmission Volvo (Volvo). Because of the transmission fluid contaminated by abrasive products, the automatic transmission hydroblock is primarily, therefore it is necessary to understand that the quality of the operation of the automatic transmission directly depends on the state of the working fluid. Replacing butter in Volvo XC70 automatic transmission 2012 release is the next, already 2nd replacement on this car, the original oil in the Volvo- Volvo 31256775 box is used.
Primary replacing Oil automatic transmission on this Volvo XC70 was produced simultaneously S. sink radiators , refinement of the thermostat automatic transmission (now he is in constant open state) and installation of additional radiator automatic transmission .
With the previous replacement of transmission fluid, the car ran over 55 thousand km and its mileage was 120800km.
What is important to note - with an additional automatic transmission radiator from the client for the last 55 thousand kilometers, there were no complaints about the operation of the automatic transmission, pressing when switching from N per D is missing, which is extremely rare for cars from the 2011 model year of release.
P.S from the moment of updating the variety information has passed for about a year and now on 01/12/2017, the mileage of this car is selected by 195.00 km. The oil in the automatic transmission is replaced during this period twice installing Wynns on ATF WS Toyota. The box works correctly The Wynns Transerve installation is connected to the automatic transmission of the ACP. Here is the process of replacing the automatic transmission oil on the Volvo XC70 by installing Wynns. The exhaust fluid merges and shows its color. At the end of the process, it can be seen that there is already a completely clean ATF. The box temperature fell to the desired indicator and is in the range of 50 to 60 degrees. Now you can check the level in the automatic transmission. Checking the level through the control opening of AISIN TF-80SC automatic
In some cases, it may be necessary to stop the control hole 30713219 and the sealing ring 1233068 to carry out a complete procedure of the automatic transmission, 12 liters of ATF are required. A slightly more transmission fluid is taken to compensate for the mixing effect.
Types of transmission fluids can differ depending on the automatic transmission model and the year of the car.
The procedure for replacing the automatic transmission oil usually takes 2-2.5 hours.
- AW 55-51SN-5 st .Model year - from 2003-2014 - 12500 rubles. (Mobil JWS-3309 12 liters)
- TF 80SC -6 stupas. Model year 2005-2010 Generation 1 - 12500 rubles. (Mobil JWS-3309 12 liters)
- TF 80SC -6 stupas. Model year C -2011 Generation 2 - 14000 rub. (Toyota-ATF WS 12 liters)
- TF 80SC -6 stupas. Model year C-2011 Generation 2 -18000 rub. (Original oil Volvo 31256775 12 liters)
The resource and the quality of the automatic transmission is larger than half, depend on the oil used and operating conditions - and in this question cannot be trifles.
When the oil replacement is needed in the Volvo automatic transmission - the difference between the partial replacement of oil on Volvo from full
Timely replacement of oil and the use of oils of the necessary parameters and qualities will help the automatic transmission to conscientiously work out the entire period. Each missed service of this unit or the use of inappropriate oil will provide an extremely expensive repair of automatic transmission or even more expensive replacement.
According to the maintenance team, the oil change in Volvo automatic transmission should be held after 20 thousand kilometers run or after one year.
BUT B. russian conditionswhen cars are forced long stand in traffic jams, and a great risk of buying not too high-quality oil, this period is worth cutting up to 10-15 thousand kilometers .
A more frequent oil change will cost a little more expensive, but it will be much cheaper than expensive automatic transmission or replacement. Moreover, incomplete replacement of oil Quite forces to any driver.
With incomplete replacement of oil with automatic transmission, no more than 35-40% of the total oil volume is merged. Whereas full oil replacementPerformed only on a service station includes automatic transmission diagnostics, complete oil removal, flushing box, replacement oil filterWhat is impossible to do without special equipment.
In cases when drained with automatic transmission volvo Oil It has a very dark or black color, the smell of Gary, or when the automatic transmission behaves wrong, you must immediately deliver the car to the nearest one hundred dealer Center Volvo.
How to independently change the oil on the Volvo automatic transmission - instructions for replacing the oil on Volvo with your own hands
An incomplete oil change is made, as a rule, on the lift. If there is no such possibility, you can replace the oil using two jacks and special backups that are almost in any automata.
- Warming up automatic transmission
Before replacing the oil, you need to warm up the automatic transmission, passing the kilometers ten, then prepare tools and accessories - two anti-tottal stop, Two jacks, two backups, special and ordinary keys, canister for draining oil with a volume of at least four, and better than five liters. Suitable canister from oil with cropped riding. We also need a watering and hose for oil bay, as well as a new o-ring oil plug. - Raise the car
It is necessary to raise the car with one of two ways:
A) With the help of jacks, heading two jacks in front of the machine, it is necessary to lift it so that the backups stood up with the side of the body. After putting the backup, you need to weaken the jacks, omitting them in turn so that the car affects them.
C) on the lift.
- Unscrew the pallet and clean the drain plug
When the machine is installed and checked, you need to unscrew the pallet in size, supporting it. Removing and removing from under the machine pallet, it is necessary to clean the drain plug of automatic transmission with an iron brush. This operation must be carried out in glasses, in order to avoid clogging the eye falling from the tube.
Cleaning the plug is obligatory, because the dirt remaining on the pallet can get inside the automatic transmission and bring it out of order. When the cork is cleaned, you need to take the prepared container, and put it right under drain hole, closed two corks. Then these two corks carefully, avoiding the jerks with the key, and acting calm and smoothly, unscrew. The first is removed and placed separately, and the second most often falls into the oil, where the sealing ring is also falling. It is not scary. - We merge the old butter
My tube is in diesel or kerosene, and wipe the clean, not a steaming cloth, and the ring is still needed to put a new one. If possible, try not to substitute your hands under the jet of oil.
After this stage - and in the case of using the canister from under the oil - to it, it is necessary to notice the volume of the fused oil to add the same amount. A strong overflow of oil is also destroyed for automatic transmission, as well as seriously nothing. With strong increased level Cuffs and glands are squeezed, and the automatic transmission fails.
When the oil stopped dripping, both corks are washed with a diesel or kerosene, wipe off with a pure non-violent cloth, and twisted back. Do not forget to put a new sealing ring. - Lower the car to the ground
Protection is placed in place, all bolts are twisted, the car is lowered. - Pour new oil in automatic transmission and check its level
Oil through thin (by the diameter of the hole for the probe) hose and funnel, poured into automatic transmission, by volume equal to the amount of fusion.
You must start the motor, and switch the automatic transmission lever with a period of two three seconds to each of the positions. After that, the engine is turned off, and in five minutes the level of oil in the automatic transmission is checked, and if necessary, the top is needed.
If the topping is required more than half a litter of oil, then it is necessary consult the dealer or in a specialized one hundred . No more serious manipulations with automatic transmission at home are not recommended, and all other procedures, including the replacement of the automatic transmission automatic transmission, and is required to wash the automatic transmission, must be carried out at a service station official dealer Volvo.
Which oil must be purchased for replacement in Volvo automatic transmission - original oil designations for Volvo
The instructions for the operation of cars Volvo lists the oil and liquid recommended by the manufacturer, for example - Volvo 31256774..
Of course, it is desirable to use the oil specified by the type and title manufacturer, but if it is impossible to find it, you can choose analogs.
All oils for automatic transmission have type ATF. And most often specification Dexron II or DEXRON III. . And the choice of the manufacturer, by and large, is not so important.
GM oil is no worse than GM toyota oils, Castrol, Exxon-Mobil, Volvo or any other manufacturer. It is important to match the oil with climatic conditions, viscosity, and lubricating properties. .
The fill of the oil that is not suitable for these parameters, at best, will drive a noncomfortable car driving, and at worst it will greatly reduce the operation of the automatic transmission. Therefore, the important task of the car enthusiast - purchase real oil , the name of which is on the label, not a fake. Otherwise, the probability of failure of the automatic transmission is greatly increasing.
Spend Replace oil in Volvo automatic transmission It is necessary, since the efficiency of the mechanism by 50% depends on the quality of the oil used. Volvo XC60 Concern cars are a technique consisting of advanced components and complex mechanisms that clearly perform their functions. Oil update helps to extend the gearbox resource, allows you to work with 100% efficiency
How often it is necessary to change the oil in the box
Automatic gearbox that you need to replace the oil will report on on-board computer. Many masters advise not waiting for the Volvo XC90 electronic module signal, and after passing 40-50 thousand km to contact the car service to update lubrication. Repair of the aggregate S. automatic control It is expensive, so maintenance need to be carried out in a timely manner. This not only increases the guaranteed service life, but also avoids repair on mileage up to 200 thousand km. By purchasing oil to replace the oil into the automatic transmission of a certain brand and quality, the car owner take care of the complex mechanism, increases the comfort of management, saves money, rationally investing them into the service of the unit.
How to change the oil in the box
Due to the complexity of the process of removing the waste mixture from the device there are two ways replace oil in automatic. Immediately merge the entire liquid composition will not work: in the radiator, in the control valve control valves and the area of \u200b\u200bthe hydrotransformer will remain approximately half the entire initial volume. A partial replacement consists in a pressing of fresh mixture and mix it with the previous composition and it is not a replacement!
The complete replacement of testing is a run of 12 liters of oil mixture for two hours. Called gradually in small portions, periodically a motor motor, so that after warming the oil spread across the entire system, mixed with the remaining one or two liters of the exhaust composition. As the concentration of the dirty mixture is added, it decreases, and the proportion fresh oil Increases. Latest portions of plum become lighter and approach dark cherry blossoms. The cleaner fusion composition, the better the process of extriving the stagnant composition in the hydrotransformer and the Volvo car radiator.
How to check oil quality
After a complete replacement, it is necessary to check the color and level of the oil mixture for another two or three weeks to notice the change in the shade on time, attach the missing volume. There is a danger that already during the operation of the Volvo XC70 when passing through the system, the fresh composition dilutes and raises a layer of working out, which during the replacement was a denser fraction. She did not have time to mix with oil liquid and retire from the system. In the case of a sharp darkening of the color, it is recommended to buy another 12 liters of oil and repeat the replacement process first. In this case, the exclusive order and purity will be guaranteed to the automatic transmission system.
What is better to pour in Volvo automatic transmission
To the selection of the brand high-quality oil It is necessary to approach with all seriousness. It is better not to pay attention to cheap options, as the box mechanism is quite complicated, and the repair is very expensive. Oil should not be too viscous or, on the contrary, liquid. This indicator depends not only on the brand or manufacturer, but also from the climatic conditions in which the automatic transmission will work. Operation Volvo S80, XC90 or XC60 using oil from the Volvo brand 31256775 concern - the best way For speed switching mechanism. But its high cost and deficit complicate the search and delivery process. The Motul 105784 brand can be an alternative to the expense of the expense of Mobil 3309. Some car enthusiasts trust german quality Liquid Moli. The synthetic mixture will suit Volvo XC90, XC60, XC70, S80, S60.
