Many modern cars are equipped with a manual transmission (manual transmission), including the comfortable urban small-calm of Daewoo Matiz. Care of the manual transmission and timely renewal of transmission lubrication is the key to the long-term use of the car. Otherwise, the vehicle can come to absolute disrepair, served the warranty period. In addition, breakdowns and lack of oil in the manual transmission can cause loss of control over the car and traffic accidents.
But for what signs you can understand the need to replace the transmission lubricant in Daewoo Matiz? How often should it be replaced by oil? How to pour outdated and pour fresh technical fluid? What is the difference between the procedure for a complete replacement of oil from partial lubrication update? Answers to these questions every motorist will be able to find in our article.
Insufficient oil in the MCP car
Replacing oil in the manual transmission in Daewoo Matiz should be made every 70,000 - 80,000 mileage. However, experienced motorists recommend refreshing the acting technical fluid more often, especially if the vehicle owner is enthusized with extreme driving. In addition, the cause of malfunction in the system of Daewoo Matiz can be lack of oil in the manual transmission.
Signs of insufficient volume Transmission lubricant in the gearbox Daewoo Matiz are the following nuances:
- When starting the Maewo Motor Matiz on the "idle" drive, the car tangible vibrates;
- During the ride, the car enters, it moves by jerks;
- There are problems when switching speeds;
- When driving, the mechanical transmission of the Daewo Matiz is engaged in the spare parts.
However, the cause of problems when switching transmissions can be not only a low percentage of transmission lubricant in the Transport MCPP, but also the unsatisfactory condition of the technical fluid used.
Signs of oil obsolescence In the gearbox, Daewoo Matiz are the following indicators:
- The transformation of the initial viscous fluid into a thick heterogeneous substance;
- The oil changed the color to dark brown with rusty splashes and lost transparency;
- In the lubricant itself, metal particles (chips, chips, etc.) are found;
- There is a resistant combustion and soot, which can even be felt in the vehicle cabin.
However, problems when expanding with Daewoo Matiz may occur not only with lacking or obsolescence of oil, but also with too much lubrication in the manual transmission. For this reason, it is recommended to check the amount of transmission lubrication using the probe. This item is in most modifications of Daewoo Matiz and looks like a flat rod with measuring pointers. To check the oil level in the gearbox, it is necessary to pull the dipstick, wipe it, put it in transmission lubricant again and check its level on the gauge scale. If the level of technical fluid is too low or excessively high, it should be replaced by oil in the manual transmission in Daewoo Matiz.
How to replace the oil in the manual transmission on Daewoo Matiz?
Preparing for the replacement of oil in the manual transmission in Daewoo Matiz is an important procedure, on which the success of further processes depends. Preparatory activities include:
- Selection of oil for Daewoo Matiz. To fill in the MCPP of the car of the specified brand and the model will suit any transmission lubricant with a level of viscosity 75W-90. Experienced motorists recommend using CASTROL MULTIVEHICLE 75W90 technical liquid;
- Preparation of the site for the placement of the car Daewoo Mitis. The plane for placing the car must be the most horizontal, without deflection and descents. It is best for the work on the replacement of oil in the manifestation of a garage pit or an overpass;
- Preparation of tools. List of tools To change the oil in the MCPP, Daewoo Matiz is listed below:
- Screwdrivers and wrenches;
- Passatia;
- Recycling capacity (pelvis, canister or bucket);
- Tool for filling fresh oil (technical syringe, watering can or funnel);
- Dense gloves;
- Clean rags or towels.
Attention! A motorist who decided to independently replace the exhaust oil in the MCPP Daewoo Matiz should be remembered about safety standards. In particular, it is not necessary to start work on the drainage of waste fluid during the engine running. Preheat to 120 degrees Celsius Transmission lubrication can cause deep thermal burns. Therefore, before starting the procedure, you need to stop the motor and provide a manual transmission time to full cooling.
The procedure for replacing oil in the manual transmission in Daewoo Matiz is full and partial. Let us consider in more detail each of these options for updating the transmission lubricant in the mechanical transmission of the vehicle.
Partial oil change in mechanical gearbox
Partial updating of technical fluid does not represent a special complexity. In fact, even an inexperienced auto owner can cope with this task. Step-by-step instruction of partial oil replacement in the MCPP DEU Matiza is provided below:
- Stage 1.
- drain of outdated technical fluid:
- The gearbox crater is carefully wiping from the dirt and dust accumulated on it;
- An oil suspension stopper is dispersed (with a square cross section);
- The exhaust fluid is measured in the harvested container;
- Under the hole of the drain is substituted with a total volume of up to 3 liters;
- A magnet from metal chips is cleared, then it is recommended to wipe the threaded part;
- The drain plug is spinning;
- Stage 2. - Fill fresh liquid. Through a technical syringe (which can be successfully replaced by a watering or funnel), a new transmission lubricant is poured into the control opening of the MCPP DEU MATIZ. Pour oil into the mechanical gearbox until the fluid starts to overflow through the softens of the neck of the fuel hole.
After the procedure for updating the oil in the manual transmission of DEU MATIZ, all parts of the gearbox are returned to its original position. The outdoor part of the unit is recommended to wipe from oil residues with a clean rag or absorbing synthetic towels.
Full oil change in manual transmission
The complete replacement of oil in the manual transmission on the Daewoo Matiz according to the regulations is considered necessary only if the general repair of the unit is needed or its components are strongly clogged. It is not recommended to produce this procedure, since without special equipment to achieve the desired result, it is impossible, and due to the complexity of the structure of the MCPP DEU Matiz, some details can be easily damaged.
For this reason, the motorist in need of a complete replacement of oil in the manual transmission on Daewoo Matiz is recommended to contact the maintenance station (service station). If there is no possibility, it is recommended to attract partners to work. The procedure for fulfilling the technical fluid in the transmission box of Daewoo Matiz will be the following:
- The oil pipes leading to the radiator cooling system are disconnected;
- On open channels, hoses are recorded by the transmission lubricant;
- Under the manifestation is a canister for a utilized material;
- Motor starts;
- Disposable plum and fill corks, and one of the pipes flows the old technical fluid, otherwise - a new one is poured.
It should be noted that in a service station this procedure will be made much more effective in view of the availability of special technical pumps and qualified personnel.
Replacing the oil mechanical transmission of Daewoo Matiz is a standard periodic procedure. This means that the oil should be regularly changed, which, however, can be done well.
What will take:
capacity for old oil;
syringe or supercharger for the bay of the new oil;
ratchet with head on 24 and 4-year.
When to change and how much oil is pouring on MATIZ MCPP
The periodicity of oil replacement in the Matiz box is quite interesting. If the car is new, only from the cabin, it makes sense to change the factory oil after running on zero (1-2 thousand km of run). Or change the mileage by 20,000 km when the production of new driving parts is particularly intense. After that, the transmission oil replacement interval increases slightly, and further will be every 40,000 km of mileage.
To replace the oil on the Matizer with the engine 0.8 need 2.1 liters of new oila, and the engine 1.0 will require 2.4 liters of oil. It is recommended not to save, rounded up to 2 liters, but to add even the missing 100 grams.
How to change the oil in the Matiz box
In good, the oil should be changed on the pit, lift or overpass, otherwise it is worth being prepared for additional difficulties and inconveniences. With the same purpose, it is worth using a syringe or oil supercharger, and not sophisticated, pouring oil with a hose and funnels from under the hood.
First, you should unscrew the filler tube using the key to 24. Then to substitute the tank for the old oil and unscrew the drain cork with a 4-grader. While the oil merges, remove the chips that the drain plug gathered magnet. After that, when the oil stops flowing, you can spin the cork back.
Daewoo Matiz is the city vehicle, which remains in demand in the domestic automotive market. The first cars became available in the late 1990s. A foreign car supports the installation of automatic transmission and manual transmission. Each of these boxes is distinguished by its reliability. To extend its term, it is advisable to send to the station periodically to the station.
The need to replace oil in the box
With long-term operation, Daewoo Matiz is needed to implement the general diagnosis of the vehicle. As a rule, the passage is appointed every 10,000 km of run. One of the services that can be offered in the service center is to replace the oil in the mathizer.
It is necessary to carry out a procedure for replacing fuel if the following symptoms have become observed:
- extraneous noise, grinds when switching speed modes;
- the appearance of jerks;
- the difficulty of changing gear.
The frequency of oil replacement in the high-speed box is determined by run. According to the auto regulations established for this version, the need to replace fuel occurs at 40,000 km of mileage. With frequent operation of the machine in off-road conditions, it is necessary to replace the oil in the checkpoint can at 20,000 km of run.
Periodically, it should be checked the level of fuel filled into the box. The oil level in the box can be determined based on the probe indicators. The optimal amount is the middle between the maximum and minimum values.
Red is the position of the probe
The main stages of replacement
The procedure for replacing the transmission fluid:
- When self-replaced oil in the checkpoint, you need to warm up the car system.
- Daewoo Matiz is installed on the observation pit.
- The drain cover is unscrewed. In this case, it is necessary to substitute an empty container for a drain (3-5 liters).
- There is a magnet on the traffic jam. He attracts the whole metal garbage to himself. Cork with a magnet, the thread of the drain hole is cleaned.
- A set pallet is subject to dismantling.
- The installed filter depending on the state can be replaced or cleaned of mud deposits.
- Sealant is applied.
- The plug of the fuel hole is unscrewed.
- With the help of a refueling syringe, oil is added to the box. Additionally, the fill may need if, after several km of the trip, the fuel level rate decreased.
Choose oil in automatic transmission and in MCP Matiz
The owner of this car should always make a choice in favor of original oils. It will be a guarantee that a qualitative product will be purchased, which will provide proper operation of the CAT. New oil must have resistance to extracts of external temperatures.
What kind of oil is better to use? For machines with a mechanical and automatic transmission, it takes its own combustion class. For example, a combustivity of SAE 75W-85, CASTROL MULTIVEHICLE 75W-90, and CASTROL MULTIVEHICLE 75W-90, and DEXRON II, III, will fit the mechanical checkpoint. Specified oils are perfectly coping with their tasks. In particular, they oppose the wear of the internal components of the Daewo Matiz gearbox, reduce the noise of the operation of the working unit.
Extremely popular among Russian motorists "Deu Matiz" has many advantages. Depending on the configuration, the Auto MCPP or automatic transmission is established in the car. The transmission is reliable, but it still needs to be carefully and carefully.
When violations are detected in its operation, it is necessary to take action immediately. Replacing the oil in the MATIZ gearbox is considered to be a procedure designed for the "revitalization" of the CAT.
Change of lubricant in mechanics
Menuing the machine in the mechanical gearbox is needed once forty thousand kilometers. If you bought a new car, you need to replace the oil once in twenty thousand kilometers. The change is carried out when a heated machine.
- Install the car on a special ditch.
- Wipe the transmission crankcase, unscrew the plum stop. You can use the "ratchet" having a 3/8 cross section in the form of a square.
- Put a three-liter bucket for the spent lubricant.
- After draining the oil, clean the magnetic elements. Share special threads.
- Perform cleaning and degreasing drain.
- Apply the sealant, close the plug to the end, open the oil-tapping neck.
- Through the syringe, pour the machine to the maximum tag. Screw the lid of the oil cylinder neck.
Change lubricant in automation
Structurally, the automatic box is arranged so that it is impossible to interfere in her work. However, the replacement of oil in the automatic transmission of Daewoo Matiz is sometimes necessary to implement. It is possible to change the oil in the box partially either completely. Before starting the procedure, the transmission needs to warm up. After that, install the car to the observation pit. For incomplete shift, you need to drain the car, unscrew the plum cover. Transmission pallet must be dismantled. It is advisable to perform it with a partner to avoid inclination of the pallet. Drain the remaining lubricant, wipe the spare parts with a dry cloth.
After that, dismantle and clean the oil filter. If necessary, change it to another. Next, returning everything in place, pour fresh petroleum products. Pour as much as it was fused.
It is more difficult to carry out a complete replacement of oil into the automatic transmission of Matiz, it is desirable to carry out it in the car service. How to change lubricant in the machine yourself? Remove the tubes that lead to the transmission radiator. Then connect the tubes for which it will flow into the bucket of the speaker. While the oil merges, fill the updated consumor. Motor at this time should work. By changing the car, return everything back.
When to replace lubricant, the choice of oil fluid
Daewoo Matiz presents a hatchback, equipped with a gearbox with five steps. When changing the modes there should be no extraneous sounds, jerks, sudden jolts. If this happens, you need to change the consumility.
Lubricant state must be checked weekly. When the engine is running, get a transmission probe, wipe it with a cloth, pay attention to the color. If it is almost black, it means that the oil resource is over. The level of the car must be between the upper and lower marks.
Quality of transmission oil in color Lubricants intended for mechanics are not suitable for the machine. The automaker advises to use Esso Juice 3314 in the implementation of the oil product replacement matrix in the automatic transmission. You can apply "Dexron 3". The company "Castrol" advises to use "Transmax-Z". It is necessary to pour about 4.78 liters.
For MCPP optimally 75W85 or GL-4. You can also pour 75W90. It will be enough 2.1 liters.
Universal synthetics perfectly shows itself in domestic conditions. Her advantages are:
- well performs its problem in low-temperature conditions;
- reduces the noise of the unit;
- can be used in various temperature ranges;
- opposes wear;
- reduces fuel consumption.
Recommended transmission oil Conclusion
The operational period of lubricating fluid is limited. When used, automotive parts form chips, which accumulates in the crankcase pallet. Part of the chips will stick to the magnetic elements, part is spreading along the transmission. Because of this, the unit is flawed faster. The oil filter, which is installed in the transmission, also need to be changed. The scored filter element is unable to cope with its own task.
Of course, the spare parts of the automatic transmission gearbox wear not instantly. First, the contacting details are soldered. The chips accumulate in the car. If spare parts are greatly extended, it will be impossible to fix something. To prevent such events, it is necessary to periodically replace the oil fluid in the Daewoo Matiz transmission.
Worn gear gear gear Remember that you can always contact the car service. They still exist to help inexperienced motor vehicles with vehicle maintenance. The minus appeals to the car service are cash costs. Not everyone wants to give his money for what you can do yourself.
Replacing the oil, try to use the lubricant that is recommended by the automaker. If you do not have access to it, leut the product, which has similar operational performance. The fill of the unsuitable lubricant is unlikely to lead to the output of the DVS fail, but it is better not to risk and use the optimal petroleum product recommended by the referral.
Each car owner in the process of operation and maintenance is faced with such questions, and how much and what to pour into a particular system of aggregates, both the engine, as well as - automatic transmission or manual transmission. Of course, the answers to such questions can be found in the manuals for use. But there are cases that there was a need to fill or change some kind of liquid or oil, and the manuals did not turn under hand. Therefore, to help such car owners, a table of filling volumes and grades of fuel and fuel (fuel and lubricants) of the car Daewoo Matiz are given. But it is important to remember that this table indicates the GSM brands according to the necessary parameters for the bay in the system, and which firms of the production of a fluid or oil or oil to pour into the car, this is a matter of personally of each car owner. The main thing is that fuel poured fuel and liquids correspond to the parameters specified in the manual.
The number of oils flexible and liquids in Daewoo Matiz
| System / Unit / Node | Lubricant or Special Liquid | Filling volume, l. | |
| Engine 0.8 Sohc. | Engine 1.0 SOHC. | ||
| Lubrication system: - full system - oil change (including filter) - oil change (without filter) |
Brand API SJ (ILSAC GF-III) SAE 10W-30. Cold climate - SAE 5W-30. Hot climate - SAE 15W-40 / 10W-30 | ||
| Cooling system | Ethylene glycol-based | 4.0 | 4.2 |
| Brake system | DOT-3 or DOT-4 | 0.49 | |
| Hydraulic steering mechanism | DEXRON II or DEXRON III | 1.0 | |
| Manual gearbox with main transmission assembly | SAE 75W-85W | 2.1 | |
| Automatic gearbox with main transfer assembly | ESSO JWS3314. | 4.78 | |
| Supply system: - Plastic fuel tank - Steel fuel tank |
Neeterized gasoline with octane number not lower than 91 (research method) | ||
| Air conditioning system: - refrigerant |
500+ 50 g. |
||
But it is important to remember that in addition to the knowledge of the brand of oil, the required quantity and oil and liquid in the Daewoo Matiz, it is necessary and to know the parameters of the required fuel depending on the climatic conditions of the car.
Volumes and brands of fuels in Daewoo Matiz Was Last Modified: April 8, 2016 by Administrator.
